+86-21-55215627 Ext:805info@yzxthrope.com

Categories

Yangzhou Xintianhe Rope Co.,Ltd

Tel:+86-21-55215627 Ext:805

Fax:+86-21-55215627 Ext:809

Phone:+8615267377440

Email:info@yzxthrope.com

Address:1169, Yangshupu Road, Yangpu District, Shanghai, China

Home > News > Content

The Tiger Rope Is Made Of Polyethylene Fiber

Yangzhou Xintianhe Rope Co.,Ltd | Updated: Nov 03, 2017


Tiger Rope is one of the indispensable equipment in outdoor activities, when you go to the mountain to explore or lead a dangerous coefficient of a relatively high route, with a twenty or thirty-metre tiger rope can play a key role in the moment, then you know how to store the tiger rope?

I. Cleaning and airing

Follow the manufacturer's advice to maintain the tiger rope. In general, you should often clean the tiger rope with warm water and mild soap, but some manufacturers may recommend that you do not use detergent to clean the ropes. Tiger Rope Waterproof treatment can buy after-sales service products to strengthen. The tiger rope can be put in a bath tub, washed by hand, or washed with a roller washer (the tiger rope may be wrapped around an open washer's laundry shaft). Tiger Rope、 Rinse in clean water several times after drying, Tiger Rope not directly exposed to sunlight.

Second, avoid damage

It is the most common injury to tread on a tiger rope, which will push sharp tiny particles into the skin of a rope. Over time, these tiny particles will continue to cut the nylon fiber of the tiger rope like a knife. Wear ice claws should be more careful to avoid the tiger rope, Tiger Rope because accidentally stepped on will damage the tiger rope, it is likely to have hurt the core, but the rope is not visible traces of the skin. Do not let tiger cords touch chemicals or other compounds that may cause damage.

III. Storage

Tiger ropes must be completely dry when stored. Untie all knots, Tiger Rope loosen up and store in dry places, away from sun exposure, heat, chemicals, petrochemical products and acidic substances.

IV. Replace the old with new

Inspect the leather to evaluate the rope condition. Always check your Tiger rope, especially after falling, make sure the skin is clean, no wear or soft place, and the tail end of the tiger is fused intact and not worn or dispersed. If the damage to the ice claws, excessive abrasion, cut by the rock surface or sharp angle, Tiger Rope so that the rope skin looks rotten, the strength of the tiger rope may be greatly reduced.

If there is no obvious softening point or blemish, it is difficult to decide whether to replace the new rope. There are many factors affecting the rope condition, including the frequency of use, the way of maintenance, how many times to fall and the rope age (the tiger Rope with more than 5 years should be eliminated, Tiger Rope it is recommended to file from the time of purchase). Not to savage use such as towing cars, tug of war, etc., once found not to use.

It may be wise to make a big fall behind a tiger rope, especially if some parts of the tiger rope become soft or flat. In general, the use of 90% of the tiger rope will not exceed the service life of the damage.

A certified new rope can withstand a fall of five UIAA grades, Tiger Rope but when you consider whether to replace the new rope, you still have to evaluate the past history of the tiger rope and other factors that will affect the condition of the rope. The basic principle of the tiger rope Exchange is to assume that the user is properly cleaned and stored in the rope.

V. Reel Rope

When carrying or storing a tiger rope, the tiger is usually picked up, the most commonly used is the climber rope plate or butterfly rope plate, Tiger Rope most of the climbers will prefer one of them, but both of them are equally useful.

1. The climber's rope plate

This method applies when a tiger rope is carried on a backpack. The tiger rope, left dozens of cm at the end of the rope, the tail of the other end of the rope, the longer end of the rope through the rope plate, and then repeat the winding rope, to fix the back of the rope tail. The end of the rope through the back of the small circle of the rope, and then use this rope end with a small circle to make a flat knot.

2, Butterfly Rope plate

This method is usually faster, will not tangle with the tiger rope, if not back backpack, can be comfortably tied to the body. It is important to keep the rope at the end of the line and to take care of it before using the tiger rope, which can reduce the possibility of mess the tiger rope. Tiger Rope Do not bend the rope plate in a saddle-like grasp two of the rope end, while winding the middle of the rope plate several times. Fold the rope into a small circle and hold the small circle through the large circle above the rope plate, and the small circle should be left big enough.

Then grab the rest of the rope end through the small circle, the entire rope end must be completely through. To tie the butterfly rope plate to the body, first put the rope on the back, the ends of the rope will be around the end of each side of the shoulder, and then around the back staggered on the rope plate, Tiger Rope and then around the waist back to the front of the body tied tightly.

Six, untie the rope plate

No matter which kind of reel rope is used to throw the rope on the ground, it starts to pull the rope end, which may be a group. Untie the knot that fastens the tiger rope first, then the homeopathy untie the rope dish, loosen up one circle at a time, pile the tiger rope into a heap, this procedure is called do MyField method. Tiger Rope It is a good habit to carefully unlock the rope before you make sure that you don't suddenly run out of knots or tiger ropes.

Butterfly Rope Plate

A, the tiger rope plate into saddle-shaped: b grasp two rope end, winding rope plate in the middle of several times;

D, catch the tiger rope through the rope loop: E to complete the rest of the rope section through the circle, and f the rope plate two of the end of the rope to bypass the shoulders of both sides, around the back, Tiger Rope and then bypass the rope plate. Then pull the two line along the waist to the front, and finally make a flat knot.

Eight, rope bag and waterproof cloth

These are the substitution methods of the coil. Both can protect the tiger rope in transit. The spread of waterproof cloth can avoid tiger ropes touching the ground. Rope bags and tarps, Tiger Rope while increasing weight and cost, are worthwhile in some cases, such as sports climbing.

Tiger Rope (sign rope)

Material: Polyethylene granular material production, domestic commonly known as the B-Lun rope, is made of polyethylene fiber

Packing: Roll type, tie type, style, Chuck type

Spec.: ø6mm-ø20mm

Color: Customized according to customer requirements

Number of shares: Three shares, four shares

Features: Bright color, soft touch, strong pull

Characteristics: Low temperature, chemical resistance, water absorption, Tiger Rope can float in the water, can still maintain its performance, suitable for water applications

Use: Tiger rope is mainly used in various types of ship equipment, fishing, port handling and other fields; also widely used in engineering, traffic, accidents, parking signs.